Simplicity 1693114 Manual do Operador

Print VendorInstructionsHow to use this fileOperator’s ManualsPaper Size: • 11x17• Body - 50 lbs brilliant white offset or equivalent• Cover - on pre-

6Safety Rules & InformationSAFETY DECALSThis unit has been designed and manufactured to pro-vide you with the safety and reliability you would exp

7NOTESNOTES

8Features & ControlsFigure 1. Tractor & Mower Controls A. ChokeB. Rear PTO Switch (Optional)C. ThrottleD. Headlight SwitchE. Dashboard Display

9Control Functions continued…G. Ignition Switch The ignition switch starts and stops the engine, it hasthree positions:OFF Stops the engine and shuts

10Features & Controls81418Figure 2. Dashboard Display — Models with aircooled enginesA. Rear PTO EngagedB. Cruise Control EngagedC. Hour meterD. F

11Features & ControlsFigure 4. Seat Switch Safety SystemSAFETY INTERLOCK SYSTEMThis unit is equipped with safety interlock switchesand other safet

12GENERAL OPERATING SAFETYBefore first time operation:• Be sure to read all information in the Safety andOperation sections before attempting to opera

13Operating the TractorWARNINGIf you do not understand how a specific controlfunctions, or have not yet thoroughly read theFEATURES & CONTROLS sec

14Operating the TractorFigure 7. Auxiliary Hydraulic System Function(Levers shown as viewed from Operator’s position whenseated on tractor. Quick Conn

Figure 8. Quick ConnectorsA. HosesB. Quick ConnectorC. Connector Covers15Operating the TractorABCConnecting Hydraulic HosesThe female quick connectors

THIS PAGE INTENTIONALLY BLANK(FOR PLACEMENT ONLY - DO NOT PRINT)

16MOWER DECK REMOVAL &INSTALLATIONNOTE: Perform mower removal and installation on ahard, level surface such as a concrete floor.Removing the Mower

Installing the Mower Deck1. Raise the attachment lift and slide the mower underthe tractor.2. Hook up the electrical connection (Figure 15).3. Start t

18Operating the TractorSTORAGEBefore you store your unit for the off-season, read theMaintenance and Storage instructions in the SafetyRules section,

19RegularMaintenanceMAINTENANCE SCHEDULE & PROCEDURESThe following schedule should be followed for normal care of your tractor and mower.* See the

20CHECKING / ADDING FUELCheck the fuel gauge on the dashboard display (A, Figure 19) tobe sure there is enough fuel to complete the job. To add fuel:1

4. Allow the filter to drain until all water and debris havedrained out.5. Turn the base of the filter back to close the fuel filter valvewhen finishe

22CHECK/CLEAN OIL COOLER (23HP MODELS ONLY)The oil cooler (G, Figure 21) should be cleaned every 25hours, or as necessary.CHANGE ANTIFREEZE (LIQUID CO

2301Regular MaintenanceFigure 29. Lubricating the TractorLUBRICATIONLubricate the unit at the locations shown in Figures 28through 33 as well as the f

24Regular MaintenanceGrease the ElectricLift Rod GreaseFitting YearlyGrease the Deck Belt Idler PulleyArm Grease Fitting Yearly48” Mower60” Mower54” M

25BATTERY MAINTENANCEChecking the Battery FluidNOTE: This procedure does not apply to maintenancefree batteries.1. Raise the hood to access battery.2.

OPERATOR’SMANUALLegacy / 2000 / 2900 Series20HP TractorsMfg. No. Description1692870 Legacy, 20HP Hydro1693114 Legacy, 20HP Hydro (Export)1693124 2020,

26Regular MaintenanceSERVICING THE MOWER BLADES1. Remove mower from the tractor. See MowerInstallation & Removal.2. Blades should be sharp and fre

27TroubleshootingAdjustments & ServiceTROUBLESHOOTINGWhile normal care and regular maintenance will extendthe life of your equipment, prolonged or

28Troubleshooting, Adjustment & ServiceTRACTOR TROUBLESHOOTING CONTINUEDPROBLEM CAUSE REMEDYBrake will not hold. 1. Brake is incorrectly adjusted.

29WARNINGTo avoid serious injury, perform adjustments onlywith engine stopped, key removed and tractor onlevel ground.Troubleshooting, Adjustment &

30TRACTOR PTO BELT REPLACEMENTNOTE: The PTO belts are a matched set and must bereplaced as a set. If the belts are being removed forinspection, make

31Troubleshooting, Adjustment & ServiceWARNINGBefore checking mower, shut off PTO and engine.Allow all moving parts to stop. Remove ignitionkey, t

32Troubleshooting, Adjustment & ServiceWARNINGBefore checking mower, shut off PTO and engine.Allow all moving parts to stop. Remove ignitionkey, t

33To avoid damaging belts, DO NOT PRYBELTS OVER PULLEYS.Troubleshooting, Adjustment & ServiceMOWER BELT REPLACEMENT60” Mower Drive Belt Replacemen

34Troubleshooting, Adjustment & ServiceFigure 52. 54” Mower Belt Routing Figure 53. 54” Mower Deck - Covers RemovedA. Idler Assembly Tension Spr

35Troubleshooting, Adjustment & Service48” Mower Drive Belt Replacement1. Remove the mower deck. See Mower Removal andInstallation2. Remove the s

MANUFACTURING, INC.500 N Spring Street / PO Box 997Port Washington, WI 53074-0997www.simplicitymfg.com© Copyright 2003 Simplicity Manufacturing, Inc

36ENGINE25 HP KOHLER COMMANDMake: Kohler - 4 cycle air cooledModel & Spec: See engine ID tagHorsepower: 25 hp @ 3600 rpmCylinder: 2 horizontalBore

37Section TitleTRANSMISSION - HYDROType Hydrostatic Sundstrand Model 15UPump Variable Displacement Axial TypeMotor Fixed Displacement Reversible Axial

38Parts & AccessoriesReplacement PartsTractor Drive Belt (Models w/Kohler engines) 1716996Tractor Drive Belt (Models w/Kawasaki engines)1716995PTO

1Table of ContentsTroubleshooting, Adjustments & Service ...27Troubleshooting the Tractor...27Troubleshooting t

GENERAL OPERATION• Read, understand, and follow all instructions in themanual and on the unit before starting.• Engine exhaust from this product conta

TOWED EQUIPMENT• Never allow children or others in or on towed equip-ment.• Tow only with a machine that has a hitch designedfor towing. Do not attac

4Safety Rules & InformationSERVICE AND MAINTENANCE• Use extra care in handling gasoline and other fuels.They are flammable and vapors are explosiv

5IdentificationNumbersTractor ID TagMower ID TagWhen contacting your authorized dealer for replace-ment parts, service, or information you MUST haveth