Simplicity Express Series Manual do Operador

How to use this file...(Operators Manuals)————————————————————————————————————————————–––Instructions forPrint Vendors (Paper Manuals)Paper Size: * 11

6Features & ControlsFigure 1. Tractor & Mower Controls A. Throttle / ChokeB. Steering WheelC. PTO Control LeverD. Mower Cutting Height LeverE.

7Features & ControlsSAFETY INTERLOCKSYSTEM TESTSThis unit is equipped with safety interlock switchesand other safety devices. These safety systems

8GENERAL OPERATING SAFETYBefore first time operation:• Be sure to read all information in the Safety andOperation sections before attempting to operat

STARTING THE ENGINE1. While sitting in the operator’s seat, fully depress thebrake pedal or set the parking brake. 2. Make sure that the ground speed

10Operating the TractorDRIVING THE TRACTOR1. Sit in the seat and adjust the seat so that you cancomfortably reach all the controls (see SeatAdjustment

11Operating the TractorPUSHING THE TRACTOR BY HANDHYDRO MODELS1. Disengage the PTO and turn the engine off.2. Move the transmission release lever up,

12MOWER DECK REMOVAL &INSTALLATIONRemoving the Mower DeckNOTE: Perform mower removal on a hard, level surfacesuch as a concrete floor.1. Park the

13Operating the TractorInstalling the Mower DeckNOTE: Perform mower installation on a hard, level sur-face such as a concrete floor.1. Park the tract

14Operating the TractorWARNINGNever store the unit, with gasoline in engine orfuel tank, in a heated shelter or in enclosed,poorly ventilated enclosur

15RegularMaintenanceMAINTENANCE SCHEDULE & PROCEDURESThe following schedule should be followed for normal care of your tractor and mower. ‡ Clean

THIS PAGE INTENTIONALLY BLANK

16Regular MaintenanceWARNINGGasoline is highly flammable and must behandled with care. Never fill the tank when theengine is still hot from recent ope

17Regular MaintenanceFigure 11. Engine Compartment A. Gas Tank D. Spark PlugB. Oil Fill / Dip Stick E. Oil DrainC. Air FilterABCEDAFigure 12. Mower

18Regular MaintenanceFigure 14. Hydro Transmission Fill Plug LocationFill ToBottom ofTop NotchFill PlugGEAR TRANSMISSION SERVICEThe Peerless MST-205-

19Regular MaintenanceBATTERY MAINTENANCEChecking the Battery FluidService Interval: Every 100 Hours1. Raise the seat to access battery compartment.2.

20Regular MaintenanceLUBRICATIONService Interval: Every 25 HoursLubricate the unit at the locations shown in Figures 17through 21 as well as the follo

21Regular MaintenanceFigure 20. Arbor Lubrication PointsLubricate Rear Axle ShaftsService Interval: YearlyWe recommend removing the rear wheels and lu

SERVICING THE MOWER BLADESService Interval: Every 100 Hours or As Required1. Remove mower from the tractor. See MowerInstallation & Removal.2. Bla

23Regular MaintenanceMAINTENANCE RECORDS:

24Troubleshooting,Adjustment, & ServiceTROUBLESHOOTINGWhile normal care and regular maintenance will extendthe life of your equipment, prolonged o

25Troubleshooting, Adjustment, & ServiceTroubleshooting the Tractor — ContinuedSYMPTOM PROBLEM SOLUTIONTractor drive belt slips. 1. Clutch is out

OPERATOR’SMANUALExpress Series14.5HP Gear TractorsMfg. No. Description1693452 Express, 14.5 HP Gear15.5HP Hydro TractorsMfg. No. Description1693458 Ex

26Troubleshooting, Adjustment, & ServiceSEAT ADJUSTMENTThe seat can be adjusted forward and back. Loosen thefour seat adjustment capscrews (A, Fi

27Troubleshooting, Adjustment, & ServiceFigure 29. Brake Adjustment - Gear ModelsA. Brake Cam LeverB. StopC. Adjustment Nut2-1/2 to 2-5/8Figure 3

28Troubleshooting, Adjustment, & ServiceWARNINGBefore checking mower, shut off engine anddisengage PTO. Allow all moving parts to stop.Remove igni

29Troubleshooting, Adjustment, & ServiceFigure 36. Front-to-Back Adjustment NutA. NutB. EccentricFigure 37. Handle Tension AdjustmentA. Adjustment

30Troubleshooting, Adjustment, & ServiceFigure 38. Mower Deck Belt Routing - 38” DeckA. Belt GuidesB. Idler Pulley Belt GuideMOWER BELT REPLACEMEN

31Troubleshooting, Adjustment, & ServiceTRACTOR DRIVE BELT REPLACEMENTAll Models1. Park the tractor on a level surface. Disengage thePTO, turn off

32Troubleshooting, Adjustment, & ServiceBATTERY SERVICEChecking Battery VoltageA voltmeter can be used to determine condition of bat-tery. When en

33Troubleshooting, Adjustment, & ServiceWARNINGAny procedure other than the preceding couldresult in:(1) personal injury caused by electrolytesqui

34Troubleshooting, Adjustment, & ServiceTRANSMISSION PURGINGThe following procedure applies to the Tuff Torq K-51hydrostatic transaxle. Purge the

35SpecificationsNOTE: Specifications are correct at time of printing and are subject to change without notice.ENGINE15.5 HP Briggs & Stratton Inte

MANUFACTURING, INC.500 N Spring Street / PO Box 997Port Washington, WI 53074-0997www.simplicitymfg.comwww.allislawn.comwww.masseylawn.com© Copyright

36SpecificationsCOMMON REPLACEMENT PARTSUse only genuine factory replacement parts. Do not attemptrepairs or maintenance unless proper procedures and

Lawn Care& Mowing InformationTYPES OF GRASS, CLIMATE ANDCONDITIONSA variety of grasses are commonly grown in householdlawns, but two main groups k

HOW HIGH TOMOW THE GRASSOften cutting height is amatter of personal prefer-ence. Typically, you shouldmow the grass when it is isbetween three and fiv

LC—3Lawn Care & Mowing InformationWhere possible, make one or two passes around theoutside of the area discharging the grass INTO the lawnto keep

LC—4Lawn Care & Mowing InformationMOWING METHODSProper Broadcast MowingBroadcasting, or side-discharging, disperses fine clip-pings evenly over th

LC—5Lawn Care & Mowing InformationTIPS On Dealing With ClippingsClippings are beneficial to your lawn. A common mis-conception about clippings is

LC—6Lawn Care & Mowing InformationStepped CuttingStepped cutting is sharp ridges or uneven levels left inthe lawn surface. Stepped cutting is usu

LC—7Lawn Care & Mowing InformationStingersStingers are sparse patches of uncut grass left behindthe mower. Stingers are usually caused by operato

LC—8Common International SymbolsChokeFast (Throttle)Slow (Throttle)Throttle PTO Clutch EngagedParking BrakeMower CuttingHeight AdjustmentAdditional T

Troubleshooting, Adjustments & Service ...24Troubleshooting the Tractor...24Troubleshooting the Mower ...

169XXXXMFGSimplicity Manufacturing, Inc.Port Washington, WI 53074-0997 U.S.A. SERIALXXXXXMower DeckIdentification TagTractorIdentification TagSSAAM

3Safety Rules& InformationGENERAL OPERATION• Read, understand, and follow all instructions in themanual and on the unit before starting.• Only all

4Safety Rules & InformationCHILDRENTragic accidents can occur if the operator is not alert tothe presence of children. Children are often attracte

5Safety Rules & InformationSAFETY DECALSThis unit has been designed and manufactured to pro-vide you with the safety and reliability you would exp